5 mm Wavelength Transceiver in the Monolithic Integrated Gallium Arsenide Design

Abstract

Radar sensors are most widely applied in developing collision prevention systems, security and military systems being exposed to extreme requirements in resistance to the mechanical and ecological effects. Transceiver module is the most important unit in a radar sensor assembly defining its main technical characteristics. The transceiver module importance lies in the fact that its parameters and characteristics determine largely the radar sensors efficiency as a whole (range, resolution, weight and size characteristics). Therefore, requirements to a radar sensors are referred primarily to the transceiver module. Constructing a microwave transceiver module based on the monolithic integrated circuits makes it possible to simplify the module board topology, improve manufacturability, reliability and resistance to the external mechanical effects of the entire radar sensors. Besides, it reduces the radar sensors weight, dimensions and manufacture cost, and provides import substitution of the critical circuitry. The paper describes technology, structure and methods in designing a 5 mm wavelength transceiver in the monolithic integrated gallium arsenide design based on the GaAs pHEMT technology. To separate design and manufacture technology of the diodes and transistors, a multilayer epitaxial structure of gallium arsenide was developed and produced. The paper presents results of simulating the transceiver circuit. It also provides results of the transceiver preliminary testing for resistance to the external factors. Possibility to implement the transceiver in the monolithic integral design using the domestic heterostructures is identified

Please cite this article as:

Dyukov D.I., Makartsev I.V., Nazarov A.V., et al. 5 mm wavelength transceiver in the monolithic integrated gallium arsenide design. Herald of the Bauman Moscow State Technical University, Series Instrument Engineering, 2024, no. 3 (148), pp. 104--114. EDN: XIIHRY

Литература

[1] Finkelshtein M.I. Osnovy radiolokatsii [Radar fundamentals]. Moscow, Radio i svyaz Publ., 1983.

[2] Komarov I.V., Smolskiy S.M. Osnovy teorii radiolokatsionnykh sistem s nepreryvnym izlucheniem chastotno-modulirovannykh kolebaniy [Fundamentals of radar systems theory with continuous emission of frequency-modulated oscillations]. Moscow, Goryachaya liniya-Telekom Publ., 2010.

[3] Tatarskiy B.G., ed. Mnogofunktsionalnye radiolokatsionnye sistemy [Multifunctional radar systems]. Moscow, Drofa Publ., 2007.

[4] Bakulev P.A. Radiolokatsionnye sistemy [Radar systems]. Moscow, Radiotekhnika Publ., 2004.

[5] Borzov A.B., Bistrov R.P. Millimetrovaya radiolokatsiya [Millimeter radiolocation]. Moscow, Radiotekhnika Publ., 2010.

[6] Kogan I.M. Blizhnyaya radiolokatsiya [Near field radiolocation]. Moscow, Sovetskoe radio Publ., 1973.

[7] Matsuura H., Tezuka K., Aoki I., et al. Monolithic rat-race mixers for millimeter waves. IEEE Trans., 1998, vol. 46, no. 6, pp. 839--841. DOI: https://doi.org/10.1109/22.681209

[8] Kraemer M., Ercoli M., Dragomirescu D., et al. A wideband single-balanced down-mixer for the 60 GHz band in 65 nm CMOS. Asia-Pacific Microwave Conf., 2010. Available at: https://ieeexplore.ieee.org/document/5728328

[9] Siweris H.J., Werthof A., Tischer H., et al. Low-cost GaAs pHEMT MMIC’s for millimeter-wave sensor applications. IEEE Trans., 1998, vol. 46, no. 12, pp. 2560--2567. DOI: https://doi.org/10.1109/22.739248

[10] Ferndal M., Zirath H. A comparison of topology and technology of balanced VCOs intended for use in a 60 GHz WLAN system. Linkoping Electronic Conf., 2003. Available at: https://ep.liu.se/ecp/008/posters/026/ecp00826p.pdf

[11] Kim J.G., Baek D.H., Jeon S., et al. A K-band InGaP/GaAs HBT balanced MMIC VCO. IEEE Microw. Wirel. Compon. Lett., 2003, vol. 13, no. 11, pp. 478--480. DOI: https://doi.org/10.1109/LMWC.2003.818530

[12] Kamfelt C., Kozhuharov R., Zirath H. A high purity 60 GHz-band single chip ×8 multiplier with low phase noise. 13th GaAs Symposium, 2005. Available at: https://amsacta.unibo.it/id/eprint/1267/1/GA051813.PDF

[13] Nicolson S.T., Tang K.A., Yau K.H.K., et al. A low-voltage 77 GHz automotive radar chipset. IEEE/MTT-S Int. Microwave Symposium, 2007. DOI: https://doi.org/10.1109/MWSYM.2007.380513

[14] Floyd B.A., Reynolds S.K., Pfeiffer U.R., et al. SiGe bipolar transceiver circuits operating at 60 GHz. IEEE J. Solid-State Circuits, 2005, vol. 40, no. 1, pp. 156--167. DOI: https://doi.org/10.1109/JSSC.2004.837250

[15] Kraemer M., Dragomirescu D., Plana R. Design of a very low-power, low-cost 60 GHz receiver front-end implemented in 65 nm CMOS technology. Int. J. Microw. Wirel. Technol., 2011, vol. 3, no. S2, pp. 131--138. DOI: https://doi.org/10.1017/S1759078711000067

[16] Alleaum Pf., Toussain C., Huet T., et al. Millimeter-wave SMT low cost plastic packages for automotive RADAR at 77 GHz and high data rate e-band radios. IEEE/MTT-S Int. Microwave Symposium, 2009. DOI: https://doi.org/10.1109/MWSYM.2009.5165815

[17] Maruhashi K., Ito M., Ikuina K., еt al. 60 GHz-band flip-chip MMIC modules for IEEE1394 wireless adapter. 31st European Microwave Conf., 2001, vol. 1, pp. 407--410. DOI: https://doi.org/10.1109/EUMA.2001.339147

[18] Kitazara K., Koriyama Sh., Minamiue H., et al. 77 GHz-band surface mountable ceramic package. IEEE Trans. Microw. Theory Tech., 2000, vol. 48, no 9, pp. 1488--1491. DOI: https://doi.org/10.1109/22.868999

[19] Maksimov A.Yu., Vasilenkov N.A. Metal-ceramic packages and materials from Tespribor JSC for microelectronics products. Elektronika: nauka, tekhnologiya, biznes [Electronics: Science, Technology, Business], 2018, no. 5, pp. 86--96. DOI: https://doi.org/10.22184/1992-4178.2018.176.5.86.96

[20] Phan K., Morkner H. A novel low cost enhancement mode power amplifier MMIC in SMT package for 7 to 18 GHz applications. 12th GAAS Symposium, 2004, pp. 599--602.